/ Register

  1. This site uses cookies. By continuing to use this site, you are agreeing to our use of cookies. Learn More.

Problems with my 250r 2010 Megelli

Discussion in 'Megelli 250cc' started by Scott, Aug 30, 2013.

Page 1 of 5
  1. Scott

    Scott Member

    Messages:
    32
    Likes Received:
    18
    Trophy Points:
    18
    Joined:
    Aug 30, 2013
    Gender:
    Male
    My Bike:
    2010 250r megilli
    As it says above I've recently purchased a 250 megilli 2010 model. Can anyone tell me how the check the oil as I can' t seem to find the sight glass nor is there a dipstick on the bung.

    Also just wondering if I change the rear sprocket to a smaller one will it give me more top end speed.
     
    Scott, Aug 30, 2013
    #1
  2. kiffsta

    kiffsta Senior Member

    Messages:
    9,066
    Likes Received:
    6,872
    Trophy Points:
    1,168
    Joined:
    Aug 7, 2010
    Gender:
    Male
    Location:
    Brisbane
    Hey Scott

    Your sight glass is on the rh side of the bike, see pics for more info

    cheers

    Chris

    Megelli_1.JPG Megelli2.JPG
     
    kiffsta, Aug 30, 2013
    #2
  3. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    Increasing /decreasing the number of teeth on the front and/or rear sprocket will increase top speed /lower acceleration and vice versa.

    Start with having a look here ...... :thumb_ups:

    http://www.gearingcommander.com/
     
    GreyImport, Aug 30, 2013
    #3
  4. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    with the sight glass you needto hold the bike straight and not leaning.. if the glass is dirty you need to take the clutch housing cover off and is a big job requiring engine removal. when oil is drained use teflon tape on thread for a good seal.otherwise oil drips end up in wide area on lower left hand side fairing.10-40 semi synthetic oil and if the bike is hard to start when hot adjust tappets. 6thou inlet and 8 thou exhaust.to get to oil straner the fairing on rhs needs to be removed. filter can be washed in petrol. latest filter is pleated paper?
     
    risky, Aug 30, 2013
    #4
  5. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    forgot to add latest motor has more grunt and different gear ratio,s and gearshift drum.

    also WELCOME TO THE GROUP.a kit was sold that had a smaller front sprocket and was called[ i think]speed kit and cost $300. but may have had 2 sprockets and fitting. .give sinh a ring at motorsport imports and he will give you the lowdown as they also had a racing team. if you take the removable air filter lid off the airbox you pick up 1 and a half horsepower. .need to remove seat and petrol tank , then 6 self tappers.make sure you turn the petrol tap off.where are yoiu located ? if in newcastle happy to help.remember weight of rider also influences speed.top should be around 140 km/h if properly tuned.
     
    risky, Aug 30, 2013
    #5
  6. Scott

    Scott Member

    Messages:
    32
    Likes Received:
    18
    Trophy Points:
    18
    Joined:
    Aug 30, 2013
    Gender:
    Male
    My Bike:
    2010 250r megilli
    Thanks guys for all your help. It's good to have people to ask questions as all the motor bike shops here don't like the brand megilli and just keep telling me to get rid of it but I haven't had a problem with the bike so far fingers crossed. I think they are a neat little bike,light,easy to ride I only use mine to ride to work and back and it's all 60klms.
     
    • Like Like x 1
    Scott, Aug 31, 2013
    #6
  7. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    scott, what tyres do you have on? if magsports you wil get mileage but for more feel and grip either pirelli speed demons or i use michelin sport activ.in imprial measurement you should get 73 miles per gallon on 95 or 98. 4.5640 litres to imperial gallon.

    also if battery goes flat use a motobatt and on the new model coming out have a positive and negative wire from battery toa hidden but accessible area to charge battery without taking fuel tank off.
     
    Last edited by a moderator: Aug 31, 2013
    risky, Aug 31, 2013
    #7
  8. Scott

    Scott Member

    Messages:
    32
    Likes Received:
    18
    Trophy Points:
    18
    Joined:
    Aug 30, 2013
    Gender:
    Male
    My Bike:
    2010 250r megilli
    Thanks risky ill have a look tomorrow I live in qld I've had no dramas starting it yet but I will have a look at the tyres I have on it and let you know one thing that I do need for the bike is a new rear shock I called a megilli dealer in vic the other day and they were very help full I just gotta order as they had none in stock
     
    Scott, Aug 31, 2013
    #8
  9. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    What is wrong with the rear shock?
    Im no suspension expert but its only 3 years old ....... unless Charlie Boorman rode the bike across Europe then it might be shagged out.
     
    Last edited: Aug 31, 2013
    GreyImport, Aug 31, 2013
    #9
  10. Scott

    Scott Member

    Messages:
    32
    Likes Received:
    18
    Trophy Points:
    18
    Joined:
    Aug 30, 2013
    Gender:
    Male
    My Bike:
    2010 250r megilli
    It's just really bouncy I've stiffened it up by winding the nut up on the spring but still very bouncy I've takin it to bike shops who have told me that the rear shock is buggered but in saying that the bike made it through road worthy even after I asked them about it. And they said it was fine so I'm not sure one person says one thing then other says something differant. I'm no machinic so I ask people.also I've searched all over the bike and I can't seem to see the sight glass for the oil anywhere. So I'm a bit lost at the moment.
     
    Scott, Aug 31, 2013
    #10
  11. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    So the bike shop has contradicted itself on that one .... so lets forget them

    Getting suspension right can get very complicated but on a simple smaller bike theres not alot of "setup" to do.
    Also make sure your tyre pressures are correct.

    What u are doing is changing the pre-load on the shock but it requires more than just "winding the nut"

    Theres a ton of info online about setting suspension and pre load ....but here a fairly simple explanation ....

    http://2fiftycc.com/index.php?threads/motorcycle-suspension-sag-adjustment.1134/

    Also heres the user manual 2 part "Maintenance Schedule" for the rear suspension..

    shock maintenance 1.jpg shock maintenance 2.jpg
     
    GreyImport, Aug 31, 2013
    #11
  12. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    re shock contact sinh at motorsport imports who bring the bikes in and the spares that the dealers obtain.[02 87851400]phone and say john from newcastle recommended you speak to him. i doubt the shock is stuffed.
     
    risky, Sep 1, 2013
    #12
  13. Murdo

    Murdo The Good Doctor Staff Member Contributing Member Ride and Events Crew

    Messages:
    6,400
    Likes Received:
    4,788
    Trophy Points:
    1,148
    Joined:
    May 4, 2013
    Gender:
    Male
    Occupation:
    Retired
    Location:
    Tamworth, NSW
    My Bike:
    1937 Royal Enfield 250, CF Moto 250 V5, Honda's XL250, CBR250, FT500 plus a few others.
    Sounds like it might have lost air pressure.
     
    Murdo, Sep 1, 2013
    #13
  14. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    GreyImport, Sep 1, 2013
    #14
  15. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    is your bike air cooled or liquid cooled with radiator.the pictures are for the liquid cooled. air cooled zongshen motors have the sight glass at the lower front of the clutch housing and if your bike has fairings the lower front right would need to be removed. if you put a watch in front of clutch housing look between 4 and 5 on dial.
     
    • Like Like x 1
    risky, Sep 1, 2013
    #15
  16. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    Is this what you are referring to risky?

    megelli_naked.jpg
     
    GreyImport, Sep 1, 2013
    #16
  17. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    that is the 125 motor but YES. the 250 is a little different.
     
    risky, Sep 1, 2013
    #17
  18. GreyImport

    GreyImport Administrator Staff Member The Chief Contributing Member

    Messages:
    10,929
    Likes Received:
    6,720
    Trophy Points:
    1,168
    Joined:
    Jun 14, 2012
    Gender:
    Male
    Occupation:
    Between a Rock and a Hard Place
    Location:
    North by NW NSW Oztralia - Tamworth
    My Bike:
    *Kawasaki ZXR250C *Yamaha FZR250R 3LN1 *Yamaha FZR400 *Triumph Bonneville 750 T140V *Triumph Daytona 675 *Triumph Tiger 800XC
    yea ... that was the just the first pic that I found on google .....:thumb_ups:
     
    GreyImport, Sep 1, 2013
    #18
  19. Scott

    Scott Member

    Messages:
    32
    Likes Received:
    18
    Trophy Points:
    18
    Joined:
    Aug 30, 2013
    Gender:
    Male
    My Bike:
    2010 250r megilli
    It's air cooled and I has fairings so I may have to take the bottom right hand one off thanks guys again you have all been such a great help.
     
    • Like Like x 1
    Scott, Sep 1, 2013
    #19
  20. risky

    risky risky

    Messages:
    4,555
    Likes Received:
    1,177
    Trophy Points:
    923
    Joined:
    Nov 4, 2012
    Gender:
    Male
    Occupation:
    risky by name AND actions
    Location:
    newcastle,australia
    My Bike:
    honda ca77, megelli x2,fzr yamaha x 5 ,maxim,cb750.cb600 hornet,zxr250,marusho magnum electra.
    no problem, i had to walk out back door and check the maxim which has the same motor but has twin disc front brakes.the air cooled motors have less power than the radiator ones but the same frame so if you buy a write off you can swap the parts over. these bikes do have a few idiosyncrecies and rear suspension handling is one of them. changed tyres help. also tyre pressure.lets say i now do more than 50k in the wet.
     
    risky, Sep 1, 2013
    #20
Page 1 of 5

Share This Page