Help Zeal - replacing brake and clutch levers

Discussion in 'Yamaha 250cc In-Line 4's' started by fzxcraignz, Jun 1, 2019.

  1. fzxcraignz

    fzxcraignz Active Member

    Messages:
    2
    Likes Received:
    0
    Trophy Points:
    65
    Location:
    New Zealand
    Hi all,

    Trying to install after market levers on my 92 Zeal, hit a snag when trying to replace the broken brake lever. Can't remove the swivel piece in the middle to use with new lever. Is this even possible or do I need to find a new one somewhere?

    IMG_4721.JPG IMG_4722.JPG IMG_4723.JPG IMG_4724.JPG
     
  2. Linkin

    Linkin The Mechanic Premium Member Contributing Member Dirty Wheel Club

    Messages:
    4,741
    Likes Received:
    2,886
    Trophy Points:
    943
    Location:
    Sydney NSW
    You need to remove the circlip. It is visible on the first picture. Use two small flat blade screwdrivers and apply even pressure wherever you can get them in. Don't lose it! It'll want to ping away on you. And don't stab yourself with the screwdrivers :)
     
  3. fzxcraignz

    fzxcraignz Active Member

    Messages:
    2
    Likes Received:
    0
    Trophy Points:
    65
    Location:
    New Zealand
    cheers for that, have been trying! will give it another go :)
     
  4. jmw76

    jmw76 Well-Known Member

    Messages:
    1,170
    Likes Received:
    600
    Trophy Points:
    498
    Location:
    Melbourne, Australia
    Try tapping a flat piece of steel (same thickness as circlip) into the groove where the open ends of the circlip are.
    This may be enough to push the circlip out a bit so you can get a small screwdriver under it and flick it off.
     
    • Like Like x 1
  5. my67xr

    my67xr Bike Enthusiast Staff Member Premium Member Contributing Member

    Messages:
    4,313
    Likes Received:
    2,384
    Trophy Points:
    898
    Location:
    Adelaide, South Australia
    I'm guessing that circlip look's like this one

    [​IMG]

    Just get a small flat head screwdriver and push it in where the arrow is marked, then give it a twist either way and try levering it out
    If you put a finger from your other hand near the back of the circlip or even a cupped hand over it you may be able to catch it as it comes out
    Do it somewhere there isn't a heap of stuff on the ground, or with a lot of hiding places

    fzx brake lever.JPG
     
    • Agree Agree x 1

Share This Page